Offical-Logo
Offical-Logo
Zhengzhou, Henan China
24 hours At your service

compressive strength of concrete made with quarry dust

  • Home
  • / Product
  • / compressive strength of concrete made with quarry dust

Compressive Strength of Concrete Made with Quarry Rock ...

the compressive strength of quarry dust concrete is comparatively 10-12 percent more than that of similar mix of conventional concrete. Studies reported elsewhere supported

Get PriceEmail contact

compressive strength of concrete made with quarry dust

COMPARING THE COMPRESSIVE AND FLEXURAL . 2020-10-2 Abstract. This study tried to compare the flexural strength of concrete made with riversand and quarry dust as fine aggregate.River sand was collected from Osogbo, Osun State, replaced at 0-100% at intervals of 10% with quarry dust gotten from Wasimi, Osun State, Nigeria.Abstract Common river sand is expensive due to the excessive cost

Get PriceEmail contact

Compressive strength of concrete made with quarry dust ...

Application of quarry dust in concrete construction Flat. Mix design has been developed for three grades using design an approach IS, ACI, USBR, RNNo4 and BRITISH for both conventional concrete and quarry dust concrete Tests were conducted on cubes and beams to study the strength of concrete made of Quarry Rock Dust and the results were compared with the Natural Sand Concrete

Get PriceEmail contact

Comparing the Compressive Strengths of Concrete Made with ...

Table 10 . Comparison of the compressive strength of concret e made with quarry dust and that made with river sand as fine aggregate after 28 days curing (Q = quarry dust, S = river sand) . S/N Mix ratios Water content Cube strength, Q (N/mm 2) Water content Cube strength S (N/mm 2) 1 0.45:1:1:2.5 0.45 21.00 0.52 15. 09

Get PriceEmail contact

Comparing the Compressive Strengths of Concrete Made

23-07-2014  This work is focused on the use of quarry dust as a total replacement to river sand in the production of concrete, and comparing the results (compressive strength) to that obtained from conversional concrete made with river sand

Get PriceEmail contact

COMPARING THE COMPRESSIVE AND FLEXURAL STRENGTH

At 21 days curing period, the study shows the average compressive strength (CS) of concrete as; 22.31, 22.98, 23.21, 23.81, 24.47, 25.17, 23.02, 21.82, 20.95, 20.22, 18.27 KN/mm2 for 100:0, 90:10, 80:20, 70:30, 40:60, 50:50, 40:60, 30:70, 20:80, 10:90, 0:100 replacement of sand by quarry dust. 28 days curing period yields compressive strength of 24.51, 24.95, 25.31, 25.83, 26.34, 27.11, 24.82, 23.62,

Get PriceEmail contact

Comparing the compressive strength of concrete made

Tests were conducted on cubes to study the strength of concrete made of Quarry Rock Dust and the results were compared with the Natural Sand Concrete. An attempt has also been made to durability studies on Quarry Rock Dust when compared with the Natural Sand concrete. It is found that the compressive, flexural strength and Durability Studies of ...

Get PriceEmail contact

Analysis of Concrete Made from Quarry Dust

cement, fine aggregate, coarse aggregate, quarry dust. The examples were casted for M25 grade of concrete by supplanting the cement 0%, 5%, 10%, 15% and 20% by quarry dust and tested for workability by slump test, compressive strength, flexure strength and split tensile test at the age of 7, 14, 28 and 50 days.

Get PriceEmail contact

Effect of Quarry Dust on High Performance Concrete

Hudson(1997) reported that the strength of Quarry Rock Dust concrete is comparatively 10-12 percent more than that of similar mix of Conventional Concrete. Also the result of this investigation shows that drying shrinkage strains of Quarry Rock Dust concrete are quite large to the shrinkage strain of Conventional Concrete.

Get PriceEmail contact

compressive strength of concrete made with quarry dust

Quarry Dust Concrete ketelservicenederland. The flexural strength of concrete made with quarry dust as fine aggregate is higher (about 4.3%) than conventional river sand concrete. 2. The 10–15% rule of thumb was found to be applicable in the estimation of flexural strength of quarrysand concrete based on its compressive strength.

Get PriceEmail contact

compressive strength of concrete made with quarry dust

COMPARING THE COMPRESSIVE AND FLEXURAL . 2020-10-2 Abstract. This study tried to compare the flexural strength of concrete made with riversand and quarry dust as fine aggregate.River sand was collected from Osogbo, Osun State, replaced at 0-100% at intervals of 10% with quarry dust gotten from Wasimi, Osun State, Nigeria.Abstract Common river sand is expensive due to the excessive cost

Get PriceEmail contact

Comparing the Compressive Strengths of Concrete Made with ...

Table 10 . Comparison of the compressive strength of concret e made with quarry dust and that made with river sand as fine aggregate after 28 days curing (Q = quarry dust, S = river sand) . S/N Mix ratios Water content Cube strength, Q (N/mm 2) Water content Cube strength S (N/mm 2) 1 0.45:1:1:2.5 0.45 21.00 0.52 15. 09

Get PriceEmail contact

Compressive strength of concrete made with quarry

Application of quarry dust in concrete construction Flat. Mix design has been developed for three grades using design an approach IS, ACI, USBR, RNNo4 and BRITISH for both conventional concrete and quarry dust concrete Tests were conducted on cubes and beams to study the strength of concrete made of Quarry Rock Dust and the results were compared with the Natural Sand Concrete

Get PriceEmail contact

Comparing the Compressive Strengths of Concrete Made

This work is focused on the use of quarry dust as a total replacement to river sand in the production of concrete, and comparing the results (compressive strength) to that obtained from conversional concrete made with river sand

Get PriceEmail contact

Comparing the compressive strength of concrete made

An attempt has also been made to durability studies on Quarry Rock Dust when compared with the Natural Sand concrete. It is found that the compressive, flexural strength and Durability Studies of concrete made of Quarry Rock Dust are nearly 10% more than the conventional concrete....

Get PriceEmail contact

Stone Dust in Concrete: Effect on Compressive Strength

found that the compressive and flexural strength of concrete made of Quarry Rock Dust are nearly 10% more than the conventional concrete (Suribabu et al., 2015). In the present study it is proposed to investigate the optimum replacement of river sand with stone dust for concrete in term of compressive strength performance at 7 days and 28 days. II.

Get PriceEmail contact

compressive strength of concrete made with quarry dust

Quarry Dust Concrete ketelservicenederland. The flexural strength of concrete made with quarry dust as fine aggregate is higher (about 4.3%) than conventional river sand concrete. 2. The 10–15% rule of thumb was found to be applicable in the estimation of flexural strength of quarrysand concrete based on its compressive strength.

Get PriceEmail contact

Improved Concrete Properties Using Quarry Dust as ...

Quarry dust is known to increase the strength of concrete over concrete made with equal quantities of river sand. The Compressive strength of quarry dust concrete continues to increase with age for all the percentage of quarry dust contents.

Get PriceEmail contact

Use of Quarry Fine as Partial Replacement of Concrete as a ...

Concrete with quarry dust as fine aggregate In a study in Thailand by Khamput [11] on the compressive strength of concrete using quarry dust as fine aggregate and mixing with admixture type E, it was found that with 70% quarry dust the concrete produced compared well with normal concrete. He

Get PriceEmail contact

Disqussion COMPARATIVE ANALYSIS OF STRENGTH OF

It was also aimed to know if quarry dust, which is available from crusher units in many areas provides a viable alternative for sharp sand in concrete. Scope of Study ; This project work focuses on the comparative analysis of strength of concrete using sharp sand from the bed of Unwana river in Afikpo North L.G.A and quarry dust from Amasiri ...

Get PriceEmail contact

Comparing the compressive strength of concrete made

Tests were conducted on cubes to study the strength of concrete made of Quarry Rock Dust and the results were compared with the Natural Sand Concrete. An attempt has also been made to durability studies on Quarry Rock Dust when compared with the Natural Sand concrete. It is found that the compressive, flexural strength and Durability Studies of concrete made of Quarry Rock Dust are

Get PriceEmail contact

An Experimental Study on Compressive Strength and ...

Strength of Concrete. Cement is being replaced with different types of waste materials to achieve the aforementioned benefits. This research paper reveals the effect of the partial replacement of cement with the Stone Quarry Dust on Compressive Strength and Splitting Tensile Strength of concrete

Get PriceEmail contact

Elasticity and Durability of Concrete Made With Quarry ...

compressive strength of concrete made with quarry dust as fine aggregate instead of sand and 10mm washed aggregate instead of conventional granite. However, there is need to determine the elasticity and the durability of the concrete made from these

Get PriceEmail contact

Comparing The Compressive Strength Of Concrete

24-08-2017  Durability Studies were done for concrete with Quarry Rock Dust and compared with the Conventional Concrete. 1.2 Scope of Study. This project is limited to using quarry dust in making concrete and also using river sand to make. The compressive strength of quarry dust and river sand are determined and their compressive strength is been compared.

Get PriceEmail contact

compressive strength of concrete made with quarry dust

Quarry Dust Concrete ketelservicenederland. The flexural strength of concrete made with quarry dust as fine aggregate is higher (about 4.3%) than conventional river sand concrete. 2. The 10–15% rule of thumb was found to be applicable in the estimation of flexural strength of quarrysand concrete based on its compressive strength.

Get PriceEmail contact

Improved Concrete Properties Using Quarry Dust as ...

Quarry dust is known to increase the strength of concrete over concrete made with equal quantities of river sand. The Compressive strength of quarry dust concrete continues to increase with age for all the percentage of quarry dust contents.

Get PriceEmail contact

Effect of quarry rock dust on the flexural strength of ...

01-06-2018  From the results, it was observed that the flexural strength of concrete with 25% and 100% quarry dust were respectively 2% and 4.3% higher compared with concrete with no quarry dust. By carrying out regression analysis, empirical formulas in the form y

Get PriceEmail contact

Introduction to Quarry-Dust as Partial Replacement ...

The results has shown that the compressive strength of quarry dust concrete is 10-12% more along with durability under sulphate and acid action.

Get PriceEmail contact

Disqussion COMPARATIVE ANALYSIS OF STRENGTH OF

It was also aimed to know if quarry dust, which is available from crusher units in many areas provides a viable alternative for sharp sand in concrete. Scope of Study ; This project work focuses on the comparative analysis of strength of concrete using sharp sand from the bed of Unwana river in Afikpo North L.G.A and quarry dust from Amasiri ...

Get PriceEmail contact

Characteristic studies on the mechanical properties of ...

Compressive strength results of various concrete mixtures. Mix ID Cement (kg/m 3) F/C (kg/m 3) Compressive strength of concrete (MPa) without quarry dust with quarry dust 7 days 28 days 56 days 7 days 28 days 56 days Mix 1 300 0.6 23.05 40.20 42.10 21.3 28.2 29.9 0.7 18.70 25.63 29.10 23.53 25.43 33.63

Get PriceEmail contact